<dt id="gkxrg"></dt>
  • 歡迎光臨山汽集團公司官網!
    400-879-1999
    在線購機
    點擊撥打服務熱線:400-879-1999
    您現在所在的位置: 首頁> 自動混凝土攪拌機知識 > 行業資訊 >
    站内搜索
    自動混凝土攪拌機知識
    關于山汽

    聯系人:劉老師

    電話:400-879-1999

    公司:山東山汽工程機械(集團)有限公司

    地址:山東省萊州市206國道與308省道交叉口東南50米

    全自動混凝土攪拌車漏油現象怎麼避免?

    所屬分類:行業資訊 發布時間:2020-12-19 來源:http://jstengda.cn/ 浏覽量:18

      避免單向閥、通氣閥堵死:由此引起箱殼内溫度升高,油氣充滿整個空間、排放不出去,使箱殼内壓力升高潤滑油消耗增加和更換周期縮短。混凝土攪拌車發動機通氣系統堵塞後,增加了活塞的運動阻力,使油耗增加。由于箱殼内外氣壓差的作用,往往會引起密封薄弱處漏油。因此需對全自動攪拌車進行定期檢查、疏通、清洗;
      Avoid blocking of one-way valve and vent valve: as a result, the temperature in the case will rise, the oil and gas will fill the whole space and cannot be discharged, which will increase the pressure in the case, increase the consumption of lubricating oil and shorten the replacement period. After the engine ventilation system of concrete mixer truck is blocked, the movement resistance of piston is increased and the fuel consumption is increased. Because of the pressure difference between the inside and outside of the case, oil leakage often occurs at the weak part of the seal. Therefore, it is necessary to regularly inspect, dredge and clean the small concrete mixer;
      重視襯墊作用:混凝土攪拌車靜置部位零部件之間的襯墊起着防漏密封作用。若在材料、制作質量及安裝上不符合技術規範,就起不到密封防漏作用,甚至發生事故。如油底殼或氣門罩蓋,由于接觸面積大而不易壓實,由此造成漏油;
      pay attention to the liner function: the gasket between the stationary parts of the small concrete mixer plays a leak proof and sealing role. If the material, manufacturing quality and installation do not meet the technical specifications, it will not play a role in sealing and leakage prevention, and even accidents will occur. For example, the oil pan or valve cover is not easy to compact due to its large contact area, resulting in oil leakage;
                全自動攪拌車
      混凝土攪拌車上各類緊固螺母都需按規定的扭矩擰緊:過松壓不緊襯墊會滲漏;過緊又會使螺孔周圍金屬凸起或将絲扣努而引起漏油。另外,油底殼放油螺塞若未擰緊或回松脫落,容易造成機油流失,繼而發生“燒瓦抱軸”的機損事故;
      all kinds of fastening nuts on the small concrete mixer truck should be tightened according to the specified torque: the gasket will leak if it is too loose or not tight; if it is too tight, the metal around the screw hole will bulge or the screw thread will buckle and cause oil leakage. In addition, if the oil drain plug of the oil pan is not tightened or loosened and falls off, it is easy to cause oil loss, and then the engine damage accident of "burning bush and holding shaft" will occur;
      避免混凝土攪拌車輪毂甩油:輪毂軸承及腔内潤滑油脂過多,或其油封裝配不妥,質量不良及老化失效;制動頻繁引起的輪毂溫度過高;車軸螺母松動等都會引起混凝土攪拌車輪毂甩油。因此要用“空腔潤滑法”,疏通通氣孔;
      avoid wheel hub oil spilling of concrete mixer: excessive lubricating grease in hub bearing and cavity, or improper oil packaging, poor quality and aging failure; high temperature of wheel hub caused by frequent braking; loose axle nut, etc., will cause oil spilling from wheel hub of small concrete mixer. Therefore, "cavity lubrication method" should be used to dredge the vent hole;
      及時更換失效油封:混凝土攪拌車上很多動置部位會因安裝不妥,軸頸與油封刃口不同心,偏擺而甩油。有些油封使用過久會因橡膠老化而失去彈性。發現滲漏及時更新;
      timely replace the invalid oil seal: many movable parts on the small concrete mixer truck may throw oil due to improper installation, the journal and the oil seal edge are not concentric, and swing. Some oil seals will lose elasticity due to rubber aging. Timely update if leakage is found;
      妥善解決全自動攪拌車各類油管接頭密封:車用聯管螺母經常拆裝,容易滑絲斷扣而松脫,會引起滲油。更換聯管螺母,用研磨法解決其錐面密封,使螺母壓緊而解決密封。
      properly solve the sealing of all kinds of oil pipe joints of concrete mixer truck: the truck union nut is often disassembled and disassembled, which is easy to break the thread and loosen, which will cause oil leakage. Replace the union nut, use grinding method to solve the cone sealing, so that the nut is pressed to solve the sealing.
    熱門産品 / HOT PRODUCT
    2.6方平口攪拌車
    推薦産品

    2.6方平口攪拌車

    3.5噸地下室
    推薦産品

    3.5噸地下室

    4噸B
    推薦産品

    4噸B

    4方同步旋轉全自動攪拌車
    推薦産品

    4方同步旋轉全自動攪拌車

    3.5方C款自動混凝土攪拌車
    推薦産品

    3.5方C款自動混凝土攪拌車

    3.5方B款自動混凝土攪拌車
    推薦産品

    3.5方B款自動混凝土攪拌車

    1.2方全自動攪拌車
    推薦産品

    1.2方全自動攪拌車

    3.5方C款自動混凝土攪拌機
    推薦産品

    3.5方C款自動混凝土攪拌機

    3.5方D款平口攪拌車
    推薦産品

    3.5方D款平口攪拌車

    3.5A款方全自動攪拌車
    推薦産品

    3.5A款方全自動攪拌車

    4.0方全自動攪拌車
    推薦産品

    4.0方全自動攪拌車

    3.5B款方全自動攪拌車
    推薦産品

    3.5B款方全自動攪拌車

    自動混凝土攪拌車
    推薦産品

    自動混凝土攪拌車

    6.5方自動混凝土攪拌機
    推薦産品

    6.5方自動混凝土攪拌機

    1.8方自動混凝土攪拌車
    推薦産品

    1.8方自動混凝土攪拌車

    3.5方A款自動混凝土攪拌車
    推薦産品

    3.5方A款自動混凝土攪拌車

    1.2方平口攪拌車
    推薦産品

    1.2方平口攪拌車

    3.5方D款全自動攪拌車
    推薦産品

    3.5方D款全自動攪拌車

    2.6方全自動攪拌車
    推薦産品

    2.6方全自動攪拌車

    3.5噸A
    推薦産品

    3.5噸A

    男女激情爽爽爽免费动态图